A new approach for detoxification of landfill leachate using Trametes trogii
Article information
Abstract
Landfill leachate constitutes one of the most polluting wastewaters. Their treatment was considered difficult due to the presence of high concentration of organic matter, ammonia, toxic organic compounds and heavy metals. Biological processes were found to be effective in several cases, but they are limited by the presence of inhibitory compounds in leachate. In this study we develop a biological process for the leachate biodetoxification using Trametes trogii (T. trogii; CLBE55). Results show that laccase activity, mycelia growth and chemical oxygen demand (COD) removal efficiencies varied depending on the leachate and ammonium concentration. Indeed T. trogii was able to grow in the presence of low concentration of landfill leachate of 10 and 30%. In fact, the biomass produced was 4.7 and 3.7 g/L, respectively leading to a COD removal of 66 and 53%, respectively. However, when the concentration of the introduced leachate exceeds 30%, the treatment efficiency and particularly the COD removal decreases to reach 15% at 100% leachate. The effect of the ammonia was also studied and results showed that the addition of 5 g/L of ammonia inhibited totally the production of laccase and the COD removal.
1. Introduction
Landfill leachate (LFL) is generated as a result of the interaction between rainfall water and solids wastes disposed in landfill sites. Their high rate of organic matter, minerals, heavy metals and xenobiotic contaminants [1] constitute therefore a threat to environment and can exert serious detrimental effects on the surrounding ecosystems [2]. The implementation of an appropriate technique for the treatment of leachate depends on the characteristics of the particular waste stream [3], characteristics and age of the leachate [4]. Indeed, the removal of organic compounds based on chemical oxygen demand (COD), biological oxygen demand (BOD), and ammonium from leachate is the usual prerequisite before discharging it into natural waters [5]. Biological processes are part of the most environmental friendly and economical treatment. They offer many advantages in terms of simplicity and effectiveness [6]. However, they strongly limited by the presence of inhibitory compounds in wastewaters [7]. Recently, white rot fungus group has been intensively studied and are gaining increasing importance in the detoxification of wastewaters and removal of a wide range of pollutants [8–10]. The biodegradation capacity of organic pollutants by white rot fungi is correlated with their ability to produce various extracellular enzymes such as lignin peroxidases (LiP), manganese peroxidases (MnP) and laccases. The last ones are able to oxidize nonspecifically various phenolic and non-phenolic compounds using molecular oxygen as the final electron acceptor [11]. Fungal laccases are subjects of increased research in the last decades, because of their wide substrate’s range and their wide variety of industrial applications [12], pulp bleaching in the paper industry [13], decolorization of textile dyes [14], biosensors [15], treatment of olive mill wastewater [10] and detoxification of landfill leachate [6]. Specifically, the white-rot fungus Trametes trogii (T. trogii) has received little research attention although it is an outstanding laccase producer and its ability to degrade all lignocellulosic materials [16]. In fact, T. trogii is a worldwide-distributed white-rot basidiomycete that has been recognized as an excellent source of ligninolytic enzymes essentially laccase [17]. Their ability to dye degradation and wastewater detoxification was proved by different authors [18–20]. However, fungal treatment of young landfill leachate has not been well studied to date. The high mineral content is one of the limiting factors for the leachate’s biodetoxification by laccases. In fact, the laccase activities decrease sharply when the concentrations of Cl− is higher than 100 mM [21]. In addition, the initial ammonium concentration influences considerably laccase production [22], biomass and enzyme yield [19]. In this context, the objective of this study was to evaluate the potential of T. trogii and its extracellular laccase enzyme in the degradation of the organic matter content in the landfill leachate. The effect of the initial concentration of organic matter and ammonia on the efficiency of the treatment was assessed.
2. Materials and Methods
The experimental approach adopted in this work is summarized in Fig. 1 and the different analyzes carried out are detailed below.
2.1. Landfill Leachate Sampling
Landfill leachate was sampled from the controlled discharge of the Sfax region (Tunisia). It was taken straight from the collection box, frozen at −20°C before being used. Table 1 present the physico-chemical characteristics of the LFL.
2.2. Analytical Methods
The pH and electrical conductivity (EC) were measured using a pH-meter (Hanna instrument) and a conductivity-meter (Consort C 831) respectively. The COD was determined using the method described by Knechtel (knechtel, 1978), and the biochemical oxygen demand (BOD5) was estimated by means of a respirometer (BSB-Controlled Model Oxitop (WTW)). The total nitrogen content and N–NH4+ were analyzed by the Kjeldahl-N method. Total phenol concentrations were quantified by the colorimetric method [23]. Volatile fatty acids (VFA) were determined by a gas chromatograph (SHIMADZU) equipped with a flame ionization detector. The total concentrations of Fe, Mn, Zn, Ni, Cr and heavy metals were determined using atomic absorption flame emission spectrophotometer with a polarized Zeeman Z-6100 model (Hitachi, Japan).
2.3. Fungal Strain and Culture Conditions
The white-rot basidiomycete T. trogii (CLBE55) was isolated from decayed acacia wood from North West of Tunisia and selected for its potential of laccase production. For short term preservation, the fungus was grown on malt extract agar at 30°C for 5 to 7 d and then Petri dishes were stored at 4°C. For laccase production, T. trogii was cultured on M7 medium containing (g/L): glucose, 10; peptone, 5; yeast extract, 1; ammonium tartrate, 2; KH2PO4, 1; MgSO4·7H2O, 0.5; KCl,0.5; trace elements solution, 1 mL. The pH of the solution was adjusted to 5.5 prior to autoclaving. Production of laccase was stimulated by adding 300 μM of CuSO4 to the culture after 3 d incubation [24]. The inoculated flasks were continuously shaken on a rotary shaking incubator operating at continuous stirring of 150 rpm and at constant temperature of 30°C for 15 d. Different volumes of landfill leachate were added to the Culture in order to reach the already fixed concentration.
2.4. Laccase Assay
Laccase activity was assayed using 10 mmol/L DMP in 100 mmol/L sodium acetate buffer, pH 5 (ɛ469nm = 27,500 M−1cm−1). Enzymatic reactions were carried out at room temperature (22–25°C). One unit of enzyme activity was defined as the amount of enzyme oxidizing 1 μmol of substrate perminute in 100 mmol/L sodium acetate buffer, pH 5.
2.5. Growth Measurements
Growth was measured in terms of dry weight of washed mycelium after filtration and drying overnight at 105°C on glass-fiber filters (GF/D Whatman Inc.). Yields were expressed as grams of dry weight mycelia per liter of culture.
2.6. Phytotoxicity Tests
Phytotoxicity was estimated by the determination of the germination index (GI) according to Zucconi et al. [25] using Lepidium sativum seeds. A sample with distilled water was used as a control.
2.7. Microtoxicity Tests
Microtoxicity tests were performed by measuring the inhibition rate of bioluminescence of the bacterium Vibrio fischeri (V. fischeri), strain DSMZ 2167. A LUMIStox equipment (GmbH, Dusseldorf, Germany), in accordance with the ISO/DIS 11348-2 (1998) standard, was used for this measurement.
2.8. Ammonia Solution Addition
The NH4Cl was added at 0.5, 1.5, 3 and 5 g/L from a sterilized stock solution prepared at 200 g/L. The control corresponded only to the amount of nitrogen required in the basal medium (2 g/L) of ammonium tartrate for T. trogii.
3. Results and Discussion
3.1. Characterization of the Landfill Leachate
Physico-chemical characteristics of the leachate samples collected during the research period are summarized in Table 1.
Leachate used were of dark color due to the presence of humic substances as the most abundant organic components in the leachate [26]. The pH was in alkaline range and the electric conductivity exceeded 30 ms/cm showing a high salt level. The BOD5/COD ratio indicated the leachate low biodegradability with a high organic load expressed in COD (40 g/L), and low BOD5 (12 g/L). The turbidity and the high content of suspended matter were consistent with an important load of colloidal particles present in the effluent. The leachate was also characterized by a high nitrogen level (more than 3 g/L) which could limit bacterial activity and biodegradability [27]. Some mineral micro-pollutants were also detected in LFL. Phenolic compounds were present and exceeded largely the limit concentrations according to Tunisian standards for wastewater release. A high concentration of volatiles fatty acids (VFA) was measured with a predominance of acetic acid (245 mM) and propionic acid (136 mM). The raw leachate was very toxic for V. fischeri, leading to 100% of inhibition of bioluminescence. The toxicity of leachate was also demonstrated by seed germination test conducted with different concentrations. Germination was completely inhibited (IG (%) = 0), where the raw leachate or 1/10 diluted solution were applied. According to Zucconi et al. [25], the toxicity of raw wastewater can be overcome when it is used beyond a dilution of 50 times.
As a consequence, treatment of landfill leachate is a priority before discharge into the receiving environment. Fungal treatment using T. trogii was studied for the degradation of organic compounds and some pollutants causing environmental problems.
3.2. Fungal and Enzymatic Treatment
3.2.1. Effect of LFL concentration on COD removal, laccase and biomass production
Laccase production from T. trogii in M7 medium without any effluent (Fig. 2) showed that after eight days of monitoring, activity peaked with a value of 7,000 U/L, and then decreased gradually.
The treatment of leachate was carried out at different initial concentration of COD (40, 20, 12, 4 g/L) corresponding respectively to different dilutions (100%, 50%, 30% and 10%) to illustrate the effect of leachate dose on laccase production. A gradual decrease of laccase activity was noticed when the effluent concentration increased (Fig. 3). Indeed, a reduction of 65% was observed by adding only 10% of leachate and the maximum production was reached 2,200 U/L. The amount of laccase activity did not exceed 140 U/L and 300 U/L for raw and 50% leachate dilution, respectively. These results suggest that the laccase production inhibition in higher concentration of leachate can be attributed to the presence of high concentration of organic matter and ammonia. These data are consistent with the those of Kalčíková et al. [6] who reported a total inhibition of laccase production using 50% leachate from active landfill.
The removal of organic matter was correlated with the laccase production (Fig. 4). Indeed, an importantdecrease was observed for cultures containing 10 and 30% leachate and the COD removal reached 56.6 and 47.36%, respectively at the fourth day of treatment. After 9 d, the removal efficiencies reached the maximum of 66 and 57%, respectively. According to other previous studies [17, 28, 29], T. trogii is characterized by its degrading ability of problematic compounds presents in wastewater. Ellouze et al. [30] showed that the enzymatic system of T. trogii was involved in the degradation of organic compound and the detoxification of leachate was a consequence of the important reduction of phenols, ammonia and hydrocarbons. Similarly, [31] showed that TOC and ammonia reduction with COD increasing in the solution is related to the capacity of extracellular enzymes production. At the end of treatment, the removal of COD decreased and reached 31 and 15% for 50 and 100% leachate, respectively.
The investigation of the effect of leachate concentration on T. trogii growth (Fig. 5) showed that biomass production was significantly inhibited with the increase of leachate concentration. Indeed, biomass production was of 3.8 g/L with 10% leachate and it decreased to 3, 2.16 and 0.12 g/L with 30, 50 and 100% leachate, respectively.
3.2.2. Effect of ammonia on T. trogii growth and enzyme secretion
At adequate level, Nitrogen is an essential nutrient for protein synthesis and enzyme production by fungal organisms. The high amount of ammonia in landfill leachate could be toxic for microorganisms. In fact, it inhibits the bioactivity of microorganisms [32]. To confirm the effect of ammonia concentration on T. trogii growth and on its laccase production, different concentrations@ of NH4Cl (0.5, 1.5, 3 and 5 g/L) were added to the initial solution contained M7 media. The laccase activity was then determined for each concentration (Fig. 6).
Compared to the control, the addition of 0.5 g/L of NH4Cl causes an inhibition rate of 16 and 11% for laccase and biomass production, respectively (Fig. 7). This result agreed with the behavior of many white-rot fungi whose degradative enzymes require nitrogen limitation. However, this result is not in agreement with that of Ellouze et al. [19] who showed that until 1 g/L of NH4Cl, laccase activity was not inhibited, but beyond this concentration the metabolic pathways and the enzyme production were negatively affected because of the nitrogen catabolic repression on the microbial secondary metabolism.
This inhibition increase gradually with the addition of ammonia, it achieved 88% with the addition of 5 g/L of ammonia. At this concentration, the biomass decreased 3 folds (3.7 for the control and only 1.6 for 5 g/L ammonia added to the culture). We can conclude that the leachate biodegradability and toxicity constitute a limit for the fungal treatment. In fact, laccase activity is directly affected by organic matter and ammonia contents.
4. Conclusions
Landfill leachate showed a high level of organic matter, ammonia and salts. These compounds exert a toxic effect, since they completely inhibited the bioluminescence of V. fischeri and the germination of Lepidium sativum seeds. Fungal treatment of leachate using T. trogii was investigated. A high removal of organic matter was observed when treated a low concentration of leachate (10 and 30%). The efficiencies decrease gradually with the increase of the leachate concentration. The high ammonia level content can be a reason for these results. In fact, the addition of 5 g/L inhibited totally the treatment, with the decrease of the laccase production and then removal of organic matter. In addition, the requirement of high amount of nutrients can constitute a disadvantage of the application of fungal in landfill leachate treatment. Also, the dilution necessary for biological treatment accentuates the leachate volume problem. So, it would be better to optimize the culture conditions for this effluent in order to achieve an efficient detoxification.